Driveway and Shop Apron Coatings in Battle Ground, WA

Battle Ground is a 25-minute trip for us on SR-503, and it sees a few more frost mornings than Vancouver. That extra cold matters for driveways. Water gets into the surface, freezes, expands, and pops tiny chips off the top. On a subdivision driveway in Meadow Glade that might look like light pitting. On a heavily used shop apron out toward Venersborg, it can look like the concrete is falling apart.

The other thing we see here is gravel. Many acreage properties have a long gravel drive that ends at a concrete apron in front of the garage or shop. Every truck that comes up that drive drags rocks onto the concrete and grinds them in. A bare broom-finished slab takes that abuse poorly. A sealed or overlaid surface holds up far better.

What We Put Down on Battle Ground Concrete

For a subdivision driveway that is structurally sound but faded and stained, we clean it, apply a densifier that hardens the concrete surface, and finish with an outdoor-rated acrylic sealer with fine grit mixed in. That combination is cheap relative to replacement and keeps water out of the pores, which is what stops frost damage.

For a shop apron that has already started to spall or has tractor tire wear, sealer is not enough. We grind the loose surface off and lay down a polymer-modified overlay, 40 to 100 mils depending on the damage. It is rated for deicer, and trucks can go on it after roughly a week of curing. The grit broadcast keeps boots from sliding on a frosty morning.

Our Driveway Coatings System

Materials: Polymer overlay or densifier + acrylic sealer
Thickness: 40-100 mils
Install time: 1-2 days
Walk on it: 1-2 days after
Drive on it: about a week after
Warranty: 8 years

Salt and deicer resistant.

Acreage Aprons and Town Driveways

In Downtown Battle Ground and the older subdivisions around Heisson and Lewisville, most driveways are ordinary two-car slabs from the 1970s to 2000s. Out on acreage, the concrete is usually the apron in front of a detached shop or RV garage, often poured by the owner, broom-finished, and sometimes not quite level. We coat the concrete only. The gravel lane leading in from the road stays gravel. A lot of these pads also have hairline cracks from settling, which we fill. If a crack is wide and moving, we tell you it will show through.

Battle Ground Neighborhoods We Cover

Downtown Battle Ground, Meadow Glade, Venersborg, Lewisville, Heisson

Cost to Coat a Battle Ground Driveway or Apron

A subdivision driveway in Battle Ground is often 450 to 600 square feet, which runs $1,350 to $4,200 depending on condition. Acreage shop aprons can reach 1,000 to 1,500 square feet of concrete. At $3 to $7 a foot, that is $3,000 at the very low end and up to $10,500 for a full overlay on the big ones. Gravel is not included.

Frequently Asked Questions

Will the coating hold up to a tractor or heavy truck on my Battle Ground property?

The overlay handles pickups, trailers, and farm tractors on rubber tires without trouble once it has had about a week to cure. Steel tracks, chains, or a loader bucket dragged across it will scratch it, just like they would scratch bare concrete. Hairline marks are cosmetic and do not break the seal.

I have a long gravel driveway. Do you coat that too?

No. We coat concrete. Gravel and asphalt are a different trade. What we do is coat the concrete pad at the end of the gravel lane, in front of the house or shop, and we can talk about ways to reduce how much gravel gets carried onto it.

Frost has pitted my driveway near Battle Ground Lake. Is it too late?

If the pitting is shallow and the slab is otherwise solid, it is not too late. We grind off the loose surface and overlay it. If the concrete crumbles deep into the slab, or sections are breaking apart, a coating will not hold and replacement is the honest answer.

My shop pad was poured by the previous owner and is a little wavy. Is that a problem?

Not for a driveway coating. Unlike an interior epoxy floor, an exterior overlay follows the shape of the slab and does not need to be flat. We fill any low spots where water pools, since standing water on a frosty morning turns into ice.

How long before I can drive the truck back into the shop?

Boots on the surface are okay after one or two days. The truck, the cars, and anything heavy like a loaded dually or a tractor should stay off for about a week so the overlay reaches full cure. A cold, damp spell near Battle Ground Lake in spring or fall can stretch that a little.

Nearby Cities Where We Also Install Driveway Coatings